Document 0Lz28pmLExDpXbQro4MYagwpM

CG 01 C0DEYE-698-D J_u.N/3_/l?2 rATE") < LOT > 5547* LBS. ( EST WGT ) PROCESSES APPROVED B1 < > YE-698-D (S) FWP 05/28/82 COHTYP JOB NAME: 1YE698DMS TYPED BY: JMW EQUIP MENT PREP 1 NAME: MOLYBDATE ORANGE 1 <fOBTAIN FOR S-20 2-'i"'CALCULATE 6 SET ON BADGER METER FOR^S-23 IX 3 rjQBTAIN FOR S-28 4 lyBfBTAIN FDR S-32 5 vCfeTAlN FOR S-34 6 f/OBTAIN FOR S-38 7 f OBTAIN FOR S-41 H INTO V-351 CHECKED BY:4!w,H USE | N-CODE 1 ACCT LBS | LBS--- 84 | 108-A. 1 33-D 734 | 4--A 146 | 3-A 237 | 32-D 350 . | 3-A 70 | 711-B 64 60 .734 146 237 350 70 1 0-D 1885 1 WEIGH. IN* OPTR M}_, MKj-L, T--$dL, SMU:/. | OPTR'____ , MK T- ______% 423-D I 303 I SUN 20" <996 G) WATER INTO V-_J#^ 1 f RUN IN FROM V-354* OPTR MK , ,,F RECORD: WHL&SOfa. < 1 * 270- i * 328) Sli-H |^-'RECORD: PH < 2 * 2-3 * 7) | VS" I* ADJ TO 76* < 3625G) AT 67-69*F >" RECORD: TMP__&L.,,F ^ ,, .N'atHM.M.IV.M 1 I*-3 U-STIR 5 MIN 6 RECORD: PH_v3</ll<2.2--3.7) \%Y\ IF NECESSARY, ADJ TO PH 3*0-3*1 ASSUME 60% | I RECORD: | | NOTE: DILUTE N-7-D 10:1 WITH WATER BEFORE I L--""ADDING . ASSUME 50% I_______ | I >5"1 RECORD: G/ML <1.142-1 .144) * I ( | NOTE: IF G/ML OUT OF LIMITS FILL. OUT I I | ^'-CHECK LIST 6 ATTACH' II II^T s TIR AT 67~69*F FOR S26* TAKE 1 QT SAMPLE* | 41 -D 57-A 33-D 7-0 1 5110 !-U~ 358 10' <50 G) WATER INTO V-358 5 LI-8 1 RUN V-359 INTO V-351 & PUMP IN V-351 I `I JUNl9 1982 119 I ADJ TO 55* <2600 G) II f 20 I SIFT IN N-108-A FROM S 1/-> n II T21 I'STIR 5 MIN & RECORD: PHj^43L-.<9.0-10*0) I I |*22 1 ADJ TO PH 9.8-9*9 & RECORD: PH______ II f| ASSUME 50% |_______ I 7-D |\ ' ASSUME 60% I________I 33-D 123* T^ADD N-33-D FROM S 2 USING BADGER METER I I 124 T ADJ TO 66" <3121 G) AT 67-69*F i' | RECORD: VOL_Ms" 6 -ML-*F 125 I STIR 5 MIN A, RECORD: PHl&X<7.4-7*6) 6 T j G/ML ILuL-.< 1*080-1.083) | | NOTE IF G/ML OUT OF LIMITS FILL OUT CHECK , I 1 LIST 6 ATTACH* TAKE 1 QT SAMPLE <: . * . N39442 LQT= ____ EQUIP I MENTf COMTYP 'JOB NAME 01YE698DMS PAGE 2 DATE PRINTED: 5/28/82 i.USE ! N- IACCT !:LBS -,L OBTAIN 1 QT SAMPL.ES OF S~ 16 & S-25 . SOLUTIONS & TITRATE TWICE RECORD: LOWEST PH___ 6 ML N-10-D__________ II LOWEST PH ...___ * & ML N-iO-D ____ __ NOTIFY SUPV IF ML N-IO-D IS NOT IN RANGE 7.1-7.4 OR IF THE TWO TITRATIONS DIFFER BY MORE THAN.0.1 ML N-10-D (IF YES, FLUSH ALL EQUIPMENT & REPEAT TITRATIONS) - I I DO NOT PROCEED IF N-IO-D TITRATION IS OUT OF RANGE ' ADJUST V-358 TO OBTAIN A TITRATION PH = 2.05 (2.00-2.10) 33-D 7-D 12 WHEN S-26 TITRATION OK , STRIKE V-358 THRU SV I I BOTH UNDERSURFACE DISTRIBUTORS INTO SV IN 6 I i 16-18 MIN n,mfi *,, I | RECORD.: S^ARtf TOTAL _____ I .I NOTE: STRIKE TIME UP WHEN 1/2 VAT BOTTOM SHOWS [ l_4r"BUBBLES APPEAR IN SIGHT GLASSES. I28"T IMMEDIATELY DUMP IN N-4-A FROM S 3 . SET TIMER I I FOR .'15 MINUTES I^OURING S 28, WASH IN V-358' STIR 2 MIN i, RECORD. P'H-^sj ?--( 1 -8-2.5) I l'^PBXS',_`___ (MUST BE + ) 13.1- f STIR TOTAL OF 15 MIN. FROM S-28 & !" RECORD: TEMP.,jjC. *F (67-73#F) I DUMP N-3-A FROM S-4 I STIR 3 MIN' d^rPOUR IN N-32-D FROM S-5 | STIR 2 MIN l^i 'PUN IN USING BADGER METER. IR 3 MIN i, FLUSH ALUM LINE WITH WATER. /iTB>fitlHP .IN N-3 FROM S-6 L39H STIR '4 MIN FOR S-43 ,,------- rRiUN IN USING WEIGHT & FLOW CONTROL PANEL,,,, r 390 MK __X_, 7 JU-"" MK *____ , ,,________% I DURING S-39 SIFT N-711-B FROM S-7 INTO V-390 L<- WITH AGITATOR ON IN 1-2 MIN \ STIR- 1-2 MIN TO MILKY SOLUTION 734 3U 115-A 28-D 28-D 367 105 SV |4KT WHEN S-39 COMPLETE, IMMEDIATELY RUN IN. N-711-B 8 f | SOLUTION GRADUALLY OVER 5 MIN PERIOD INTO SV I I WATCH FOAM!!! IF FOAMING IS EXCESSIVE, STOP I dNTIL FOAM SUBSIDES. LHKfWP in JzrymiK 10 MIN Q . . ^U6T> Rec o r d : ph ^x __ (s. 8-6.0) \^f\ IF NECESSARY, ADJ TO PH 5.8-6.0 ASSUME SOX J & RECORD: PH*.._' ASSUME 667. 48 | RECORD: TIME_^^)fe__ 43^%-PEOOC.TO 153* (7619 G) STOP AGITATOR I START , FINISH /) OPTR HELPER vmtM JMsm, _ y 350 \ 128-A 350 7-D 33-D f..- **^***'*'& / DUP050046087