Document 0DqojDdJmN5DMMv6Jpdqanwm

I ABDOO 17290.0 Attachment "B" Page 7 of 14 EMPLOYEE SAFETY TRAINING 1. What people must abide by the Conoco General Plant Safety Rules and Procedures in our plant? A. Visitors B. Contractors C. Employees All of the above __________ _______________ _____________________ -- 2. Who must abide by department safety rules and regulations while in a given department area in the plant? A. Department employees only B. Visitors other than contractors Contractors Everyone 3. Good housekeeping results in improvement in: i Product output Employee morale Safety conditions and reduced injuries Product quality . All of the above 4. A person who has an injury must report the injury to: His Supervisor The security guard C. His lead operator D. The first person he sees after the injury 5. What do you use to wash a respirator? A. Wash the respirator with cold water B. Wash the respirator with hot, soapy water (^Cy Wash the respirator with warm water, mixed with a mild detergent, according to the manufacturer's instructions D. Respirators d_o not need to be washed 6. What.should an employee know in order to perform a job safely? A. How to produce more product than anyone else How to try harder The correct operating procedures for the job How to keep on the move by checking on problems ABDOti 172901 Attachment "B" Page 8___ of 14 Who must'sign the VCM Regulated Area Log sheet when entering a regulated area? A. Hourly employees B. Salaried employees C. Contractors Everyone The work^permit system is followed in the following areas of the plant: A. The /vinyl reactor and vinyl dryer areas B. Compound, dry blend, and P-1 areas C. V.C. tank farm, and yard areas <S> All areas- 9. Where and how is electrically driven equipment locked-out for repair or entry? At the breaker box with a lock B.. At the start/stop switch with a lock C. At the stop/start switch with a tag D. At the stop/start switch with a special pin only 10. Employee smoking is permited only in what areas? As specified in Department Safety Rules All office area's _________________ Maintenance Shops Designated breakroom area All areas mentioned 11. Any person who recognizes an unsafe condition or unsafe act should immediately ' report it to his: i A. Friend, if a co-worker Co-worker, if a friend $ Immediate Supervisor Security Guard E. Training Supervisor 12. A person should always wash his hands after handling any chemicals before he: A. Does the next job B. Does reports or similar paperwork C. Enters the east warehouse (D^) Eats or smokes 13. Who is authorized to operate a Fork Lift truck in the plant? A. Anyone who has driven a fork truck before A Conoco licensed operator C. An experienced driver who has operated lift trucks for two years D. Anyone whose supervisor asks him to do so. ABDOO172902 Attachment "B" Page Q of M 14. What is the correct plant phone number for sounding the plant fire alarm? A. 81 <> 61 C. 62 D. 63 , i 15. What is the correct plant phone number f i A. 61 , 62 C. 81 D. 63 r 16. What is the correct plant phone number t< , emergency or fire? 63 B. 81 C. 62 D. 61 17. Who is authorized to perform repair work Instrument mechanics only Appointed, qualified persons only C.' Shift mechanics D. Shift supervisors -18. Are all Conoco plant personnel required & Yes B. No 19. Before entering a vessel of any kind, is the vessel be blanked off? > Yes B. No 20. Which of the following equipment require A. Dryer Inlet -- B. Dryer Outlet Day Collector 21. A^rfanhole watch is required to enter the V-10 activator pit. ABDOO 172903 Attachment MBM Page 10 of 14 22. A safety line and harness must be worn when entering: (PA. V-10 activator pit Dryer burner and inlet duct C. Day Collector i 23. Gloves must be worn when: A. Opening bag boxes B. Cleaning dryers C. Bagging Resin (6) All of the above 24. vEar protection must be worn on Bird deck when in this areas for more than 30 minutes. A. B. 25. The east end of V-ll Dryer room is the primary evacuation area for the Vinyl Department. a. 425 B. No 26, There are how many Scott Air Paks in the V-ll Dryer area? i 27. The following people are responsible for housekeeping in the Dryer Areas: A. Utilities B. Dryer "A" Operator Dryer Lead Operator All of the above 28. All Dryer Personnel are authorized to drive the fork truck assigned to the Dryer Department. A. Yes B. $3) 29, Dryer Personnel are permitted to use air hose without safe-to-blow nozzles for personal cleaning. A. Yes B.